Product ID:ZEP-O-BRITE, 1038
MSDS Date:11/01/1996
FSC:7930
NIIN:01-423-1148
Status Code:A
MSDS Number: CLBZC

ZEP MFG CO DIV OF NATIONAL SERVICE INDUSTRIES

1310 SEABOARD INDUSTRIAL BLVD NW
ATLANTA, GA 30301
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Cage: 27674

ZEP MANUFACTURING COMPANY

2015 ATLANTA, GA 30318 US

Telephone: 877-428-9937

Cage: 27674

CHLORINATED TRISODIUM PHOSPHATE

CAS: 11084-85-8

RTECS: FO2000000

Fraction By Weight: 10-20%

FELDSPAR

CAS: 68476-25-5

RTECS: 1006466FP

Fraction By Weight: 60-70%

OSHA PEL 10 MG/M3 (POWDERS)

CRYSTALLINE SILICA-QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

OSHA PEL 0.1 MG/M3

ACGIH TLV: 0.1 MG/M3

Health Hazards Acute and Chronic:DUST FROM PRODUCT MAY BE IRRIT TO SKIN
& EYES. IRRIT OF SKIN ACTS BY ITCHING OR REDDENING OF SKIN. EYE
IRRIT ACTS BY WATERING, ITCHING & REDNESS. INHALATION OF DUST MAY
PRODUCE RESPIRATORY IRRITATION, ACTS AS COUGHING OR A CHOKING
SENSATION. REPEATED EXPOSURE OF THE EYES TO LOW LEVEL OF DUST CAN
PRODUCE EYE IRRITATION. REPEATED SKIN EXPOSURE PRODUCE LOCAL SKIN
DESTRUCTION/DERMATITIS. REPEATED INHA LATION CAN PRODUCE DEGREES OF
RESPIRATORY IRRITATION/LUNG DAMAGE. LONG TERM EXPOSURE TO SILICON
DIOXIDE HAS BEEN KNOWN TO PRODUCE SILICOSIS -- A LUNG DISEASE
INDICATED BY DRY COUGH & GRADUAL DECREASE IN BREATHING ABILITY.
*SEE SUPPL SAFETY
Effects of Overexposure:REPEATED SKIN EXPOSURE CAN PRODUCE LOCAL SKIN
DESTRUCT OR DERMATITIS. REPEAT INHAL OF DUST CAN PRODUCE VARYING
DEGREES OF RESPIRATORY IRRIT OR LUNG DAMAGE. LONG TERM EXPOS TO
SILICON DIOXIDE BEEN KNOW N TO CAUSE SILICOSIS, LUNG DISEASE
INDICATED BY DRY COUGH & GRADUAL DECREASE IN BREATHING ABILITY.

First Aid:SKIN:FLUSH CONTAM SKIN W/PLENTY OF WTR. CONSULT PHYSICIAN IF
IRRIT DEVELOPS. EYES: IMMED FLUSH EYES W/PLENTY WTR @ LEAST 15 MIN.
OCCASIONALLY LIFT UPPER/LOWER LIDS. GET MED ATTEN @ ONCE. INHALE:
MOVE VICTIM TO FRESH AIR. FLUSH MOUTH/NASAL PASSAGES W/WATER
REPEATEDLY. GET MED ATTEN IF IRRIT PERSIST. INGEST: DO NOT INDUCE
VOMITING. IF VICTIM IS CONSCIOUS GIVE LOTS OF WATER TO DRINK. MED
ATTEN @ ONCE

Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NONCOMBUSTIBLE
Fire Fighting Procedures:FIRE EXPOSED DRUMS SHOULD BE COOLED WITH
STREAM OF WATER.
Unusual Fire/Explosion Hazard:MAY RELEASE CHLORINE GAS WHEN EXPOSED TO
HEAT OR FLAME.

Spill Release Procedures:OBSERVE SAFETY PRECAUTIONS IN SECT 4 & 9
DURING CLEAN-UP. PICK UP SPILLED MATERIAL & PLACE IN A SUITABLE
WASTE CONTAINER. WASH AREA THOROUGHLY WITH A DETERGENT SOLUTION &
RINSE AREA WELL WITH WATER.

Handling and Storage Precautions:CLOSE CONTAINER TIGHTLY WHEN NOT IN
USE. STORE AWAY FROM SUN & HEAT. KEEP PRODUCT AWAY FROM SKIN &
EYES.
Other Precautions:NEVER MIX PRODUCT/SOLUTION WITH ANY OTHER CHEMICAL.
DO NOT ALLOW PRODUCT TO BECOME MOIST OR CONTAMINATED WITH OTHER
CHEMICAL IN STORAGE. AVOID BREATHING DUST. KEEP OUT OF REACH OF
CHILDREN.

Respiratory Protection:USE NIOSH-APPROVED DUST MASK IF DUST IS PRESENT.
Ventilation:IF DUST IS DETECTED, VENTILATE WORK AREA BY OPENING WINDOWS
AND USING EXHAUST FANS.
Protective Gloves:GLOVES RESISTANCE TO INGREDIENTS
Eye Protection:TIGHT FITTING SAFETY GLASSES
Supplemental Safety and Health
THIS MSDS DATA PERTAINS TO PRODUCT AS DISPENSED FROM CONTAINER. ADVERSE
HEALTH EFFECTS NOT EXPECTED UNDER RECOMMENDED CONDITIONS OF USE
(DILUTED) SO LONG AS PRESCRIBED SAFTETY PRECAUTIONS ARE PRACTICE D.

Solubility in Water:SEMI-SOLUBLE
Appearance and Odor:A FREE-FLOWING, YELLOWISH POWDER WITH A LEMONY
AROMA.

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AMMONIA SOLUTIONS AND STRONG ACIDS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
HYDROGEN CHLORIDE, AND SMALL AMOUNTS OF PHOSGENE & CHLORINE GAS.

Waste Disposal Methods:PRODUCT IS NOT HAZ WASTE PER RCRA. UNUSABLE
MATERIAL SHOULD BE DRUMMED & TAKEN TO A CHEMICAL OR INDUSTRIAL
LANDFILL, OR IF PERMITTED PUT INTO A SOLUTION W/WATER & FLUSH IN A
SANITARY SEWER. NEUTRALIZA TION OF PH MAY BE PREREQUISITE FOR SEWER
DISPOSAL. CONSULT LOCAL/STATE/FEDAGENCIES FOR PROPER DISPOS AL
METHOD IN YOUR AREA.

Toxicological Information:LONG TERM EXPOSURE TO SILICON DIOXIDE HAS
BEEN KNOWN TO CAUSE SILICOSIS, A LLUNG DISEASE INDICATED BY DRY
COUGH AND GRADUAL DECREASE IN BREATHING ABILITY. ONE OF THE
INGREDIENTS IN THIS PRODUCT MAY CA USE TUMORS IN LABORATORY
ANIMALS. THE APPLICABILITY OF THESE STUDIES TO HUMANS HAS NOT BEEN
ESTABLISHED.

State Regulatory Information:EPA TSCA CHEMICAL INVENTORY: ALL
INGREDIENTS ARE LISTED

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.